Doe Science news source
The DOE Science News Source is a Newswise initiative to promote research news from the Office of Science of the DOE to the public and news media.
  • 2010-10-12 09:00:00
  • Article ID: 569532

Planar Power

  • Credit: Image courtesy of PNNL.

    A flat or planar sodium-nickel chloride battery could deliver 30 percent more power at lower temperatures than its cylindrical counterpart, according to new research from DOE's Pacific Northwest National Laboratory.

RICHLAND, Wash. – A redesign of sodium-nickel chloride batteries promises to overcome some of the obstacles long associated with rechargeable batteries. Replacing their typical cylindrical shape with a flat disc design allows the battery to deliver 30 percent more power at lower temperatures, according to work published by the Department of Energy's Pacific Northwest National Laboratory in the October 8 issue of ECS Transactions, a trade journal. Researchers say these sodium-beta batteries could eventually be used in electricity substations to balance the generation and delivery of wind and solar power on to the grid.

Because the battery's main components include abundant materials such as alumina, sodium chloride and nickel, they are less expensive to manufacture than lithium-ion batteries, and could still offer the performance necessary to compete for consumers' interest. In addition, compared to other battery systems, sodium-beta batteries are safer and can help incorporate renewable energy sources into the electrical system easier.

"This planar sodium battery technology shows potential as an option for integrating more solar and wind power into our electric grid," said Carl Imhoff, electricity infrastructure sector manager at PNNL.

Sodium-beta alumina batteries have been around since the 1960s but their tubular, cylindrical shape does not allow efficient discharge of stored electrochemical energy. This inefficiency causes technical issues associated with operating at high temperatures and raises concern about the cost-effectiveness of the tubular batteries.

Lithium-ion batteries surpassed sodium-beta batteries because they perform better. However, materials for lithium batteries are limited, making them more expensive to produce. Safety also has been a concern for rechargeable lithium batteries because they can be prone to thermal runaway, a condition where the battery continually heats up until it catches fire.

"The PNNL planar battery's flat and thin design has many advantages over traditional, tubular sodium nickel chloride batteries," said PNNL Scientist Xiaochuan Lu, co-author of the paper.

To take advantage of inexpensive materials, the PNNL researchers thought a redesign of the sodium-beta batteries might overcome the technical and cost issues: the cylindrical sodium beta batteries contain a thick, solid electrolyte and cathode that create considerable resistance when the sodium ion travels back and forth between the anode and the cathode while the battery is in use. This resistance reduces the amount of power produced. To lower the resistance, temperature must be elevated. But increasing operation temperature will shorten the battery's lifespan.

The researchers then tested the performance of their redesigned sodium-nickel chloride planar batteries, which look like wafers or large buttons.

The researchers found that a planar design allows for a thinner cathode and a larger surface area for a given cell volume. Because the ions can flow in a larger area and shorter pathway, they experience lower resistance. Next, the battery's design incorporates a thin layer of solid electrolytes, which also lowers the resistance. Because of the decrease of resistance, the battery can afford to be operated at a lower temperature while maintaining a power output 30% more than a similar-sized battery with a cylindrical design.

Finally, the battery's flat components can easily be stacked in a way that produces a much more compact battery, making it an attractive option for large-scale energy storage, such as on the electrical grid.

"Our goal is to get a safer, more affordable battery into the market for energy storage. This development in battery technology gets us one step closer," said Lu.

Researchers at PNNL and EaglePicher LLC received funding from the Advanced Research Projects Agency — Energy, or ARPA-E, earlier this year to conduct the research, and will work together to improve the battery's design, lifespan and power capacity.

The research was funded by PNNL and by ARPA-E.

________________

Reference: Xiaochuan Lu, Greg Coffey, Kerry Meinhardt, Vincent Sprenkle, Zhenguo Yang, and John P. Lemmon, High Power Planar Sodium-Nickel Chloride Battery, ECS Trans. 28, 7 (2010), doi:10.1149/1.3492326, in press.

Pacific Northwest National Laboratory (www.pnl.gov) is a Department of Energy Office of Science national laboratory where interdisciplinary teams advance science and technology and deliver solutions to America's most intractable problems in energy, the environment and national security. PNNL employs 4,900 staff, has an annual budget of nearly $1.1 billion, and has been managed by Ohio-based Battelle since the lab's inception in 1965. Follow PNNL on Facebook, LinkedIn and Twitter.

See the orginal release at: http://www.pnl.gov/news/release.aspx?id=824

X
X
X
  • Filters

  • × Clear Filters

new DOE

testing new DOE

Cold and Bubbly: The Sensory Qualities that Best Quench Thirst

New research from the Monell Center finds that oral perceptions of coldness and carbonation help to reduce thirst. The findings could guide sensory approaches to increase fluid intake in populations at risk for dehydration, including the elderly, soldiers, and athletes.

J.R. Macdonald Lab receives nearly $8 million DOE grant renewal

MANHATTAN -- A nearly $8 million grant from the U.S. Department of Energy is supporting the "bread and butter" physics research at Kansas State University's James R. Macdonald Laboratory. The grant is a three-year renewal award, "Structure and Dynamics of Atoms, Ions, Molecules and Surfaces." "This big operational grant is our bread-and-butter," said Itzik Ben-Itzhak, university distinguished professor of physics and director of the J.

University contributes art to the new downtown arena

A number of Sac State artworks are joining Jeff Koons' "Coloring Book" in exhibits at the new Golden 1 Center. (Sacramento State/Rob Neep) More photosSac State Professor Rachel Clarke and alumnus Bryan Valenzuela check out the installation of Valenzuela's "Multitudes Converge" glass sculpture at the Golden 1 Center.

test videoa

test videoa

Test Head

Test Desc

New Method for Reporting Solar Data

A straightforward new way to calculate, compile, and graphically present solar radiation measurements in a format that is accessible to decision makers and the general public has been developed by researchers at the University of Texas at Austin and is described in the Journal of Renewable and Sustainable Energy.

Trapped Sunlight Cleans Water

High energy costs are one drawback of making clean water from waste effluents. According to an article in the journal Biomicrofluidics, a new system that combines two different technologies proposes to break down contaminants using the cheapest possible energy source, sunlight.

Report: Policies to Spur Renewable Energy Can Lower Energy Costs

The South could pay less for its electricity in 20 years than is currently projected if strong public policies are enacted to spur renewable energy production and use, according to a report released today by researchers at the Georgia Institute of Technology and Duke University.


  • Filters

  • × Clear Filters

Citi Grant Helps University Students Succeed

Citi Community Development, part of the Citi family of businesses, supports an innovative Academic Success Program at South Dakota State University. The program is designed to help students who have been re-admitted to SDSU following suspension due to low academic achievement.

Iowa State Engineer and Goodrich Partner to Develop Fuel Nozzles

Hui Hu, an Iowa State University associate professor of aerospace engineering, is working with engineers from the Goodrich Corp. to test and characterize the next generation of fuel nozzles.

CSB to Hold Public Hearing Tomorrow, December 15, as Part of the CSB Deepwater Horizon Investigation

CSB Board Will Hear Testimony on how Offshore Drilling is Managed and Regulated in Other Countries

Cornell Joins Team Taking Head-first Plunge Into Algae Biofuels

Cornell University researchers have joined other scientists and a biofuel research company on a mission to develop a commercial-scale algae-to-fuel facility by 2015. The effort is backed by a $9 million award from the U.S. Department of Energy.

Engineering Researchers Partner With Toyota; DOE Grant Will Further Work Toward a More Efficient Charger for Hybrid-Electric Vehicles

A $3.9 million award from the U.S. Department of Energy will allow electrical engineering researchers at the University of Arkansas to continue contributing to the development of a compact and highly efficient silicon-carbide charger for hybrid electric vehicles. The benefits of the project extend beyond vehicles into other areas, such as wind and solar power, and could lead to reduced energy consumption in the United States.

Research Looks at Alternative Power for Military

South Dakota State University has a major role in a $10 million project to deliver alternative power technologies to help the U.S. military supply power to units in the field. The three-year project began in May 2009.

Mixing Blood and Oil: Conference Tackles Similar Challenges from Two Major Industries

Scientists and engineers from two of the nation's largest industries - medicine and energy - came together this week to explore the synergies in moving oil and pumping blood.

Time Ripe to Move Energy Storage Idea Off Drawing Board

Need has caught up with Case Western Reserve University researcher Gerhard Welsch's design for a self-healing, high-energy capacitor he patented a decade ago. ARPA-E has granted Welsch $2.25 million to start producing the small and lightweight device for hybrid and electric cars and more.

Registration Open for Sandia-Sponsored 4th International Conference on Integration of Renewable and Distributed Energy Resources

Registration is open for the 4th International Conference on the Integration of Renewable and Distributed Energy Resources, the premier event for technical discussion of electric integration of new energy resources.

Advanced Energy Conference To Illuminate Latest Technologies For 21st Century Clean Energy Economy

Leading Energy Organizations to Highlight Latest Job-Producing Energy Technologies at Nov. 8-9 Conference in N.Y.C.


  • Filters

  • × Clear Filters
No articles in this channel.

Spotlight

Tuesday December 07, 2010, 05:00 PM

UC San Diego Installing 2.8 Megawatt Fuel Cell to Anchor Energy Innovation Park

University of California San Diego

Monday November 01, 2010, 12:50 PM

Rensselaer Smart Lighting Engineering Research Center Announces First Deployment of New Technology on Campus

Rensselaer Polytechnic Institute (RPI)

Friday September 10, 2010, 12:40 PM

Ithaca College Will Host Regional Clean Energy Summit

Ithaca College

Tuesday July 27, 2010, 10:30 AM

Texas Governor Announces $8.4 Million Award to Create Renewable Energy Institute

Texas Tech University

Friday May 07, 2010, 04:20 PM

Creighton University to Offer New Alternative Energy Program

Creighton University

Wednesday May 05, 2010, 09:30 AM

National Engineering Program Seeks Subject Matter Experts in Energy

JETS Junior Engineering Technical Society

Wednesday April 21, 2010, 12:30 PM

Students Using Solar Power To Create Sustainable Solutions for Haiti, Peru

Rensselaer Polytechnic Institute (RPI)

Wednesday March 03, 2010, 07:00 PM

Helping Hydrogen: Student Inventor Tackles Challenge of Hydrogen Storage

Rensselaer Polytechnic Institute (RPI)

Thursday February 04, 2010, 02:00 PM

Turning Exercise into Electricity

Furman University

Thursday November 12, 2009, 12:45 PM

Campus Leaders Showing the Way to a Sustainable, Clean Energy Future

National Wildlife Federation (NWF)

Tuesday November 03, 2009, 04:20 PM

Furman University Receives $2.5 Million DOE Grant for Geothermal Project

Furman University

Thursday September 17, 2009, 02:45 PM

Could Sorghum Become a Significant Alternative Fuel Source?

Salisbury University

Wednesday September 16, 2009, 11:15 AM

Students Navigating the Hudson River With Hydrogen Fuel Cells

Rensselaer Polytechnic Institute (RPI)

Wednesday September 16, 2009, 10:00 AM

College Presidents Flock to D.C., Urge Senate to Pass Clean Energy Bill

National Wildlife Federation (NWF)

Wednesday July 01, 2009, 04:15 PM

Northeastern Announces New Professional Master's in Energy Systems

Northeastern University

Friday October 12, 2007, 09:35 AM

Kansas Rural Schools To Receive Wind Turbines

Kansas State University

Thursday August 17, 2006, 05:30 PM

High Gas Prices Here to Stay, Says Engineering Professor

Rowan University

Wednesday May 17, 2006, 06:45 PM

Time Use Expert's 7-Year Fight for Better Gas Mileage

University of Maryland, College Park





Showing results

0-4 Of 2215